Grindmaster 5511 Bedienungsanleitung

Grindmaster Corporation4003 Collins LaneLouisville, KY 40245 USA(502) 425-4776 (800) 695-4500FAX (502) 425-4664www.grindmaster.com0501 Form# WH-33

Crathco®5311 & 5511 Manual Page 9Product Consistency Adjustment (cont.)4) When making adjustments to a thicker (colder) setting, dispense approxim

Consistency Control - Overview (cont.)In the “standby” mode the control board senses the temperature of the product in the barrel. The drive motor isc

Crathco®5311 & 5511 Manual Page 11CARE AND CLEANINGNote: Each time the freezer is disassembled, all internal freezer components must be thoroughly

Daily Cleaning Procedure (cont.)Note: The best way to remove an “O” Ring is to first wipe off all of the lubricant using a clean paper towel. Pinch th

Sanitizing Carburetor and Valve Components (cont.)8. Slide the valve plunger spring over the small end of the valve plunger and, using another clean p

Sanitizing and Refilling (cont.)11. Watch the product flowing out of the dispensing valve and close the Valve when the sanitizer remaining in the cyli

Crathco®5311 & 5511 Manual Page 15Cleaning Following Complete Disassembly of Unit (cont.)IMPORTANT: After disassembly, thoroughly scour each part

Reassembly (cont.)5. Disassemble the carburetor assembly and remove the O-Rings.Wash and sanitize all parts.6. Reinstall and lubricate the O-Rings and

How to Clean Exposed Filter:1. Slide exposed filter out of the rails by pulling forward on the filter. It is recommended toremove the filter by using

Annual Maintenance (cont.)4. Remove dasher assembly, inspect stator bearings and replace shaft seal set. (See Care and Cleaning).5. Remove rear panel

5311 FREEZER SPECIFICATIONS:ElectricalCircuit NEMA#Drive Motor1/4 hp, Capacitor Start/Run3/4 hpAir Cooled (Optional Water Cooled)175 lbs. (79.4 kg)5 g

PartDescriptionMonthlyEvery3 MonthsEvery6 MonthsAnnuallyQuantitiesto beReplacedShaft seal Inspect &replace ifnecessary1Inspect &replace ifnece

TROUBLESHOOTINGOnly a qualified service technician should perform Electrical and mechanical adjustments orrepairs. Always disconnect power before att

TROUBLESHOOTING (cont.)ProblemPossible CauseSolutionClicking sound from electrical box• Low voltage• Extension cord or improperlysized electrical wire

Crathco®5311 & 5511 Manual Page 23Exploded View Model 5311Optional X-large drip panfor units with spinnersOptional Thick Product plungerOptional D

Crathco®5311 & 5511 Manual Page 24Exploded View Model 55115511-0109-015-3-20-0015102223273032333435363738394445464748495861100107120121136137138W0

Exploded View Model 5311 Base AssemblyItem Part Number Description12345678910111214W02101690W200123W0200256W0200411W0200412W0200413W0201079W0210041W0

Crathco®5311 & 5511 Manual Page 26Exploded View Model 5511 Base Assembly5511-0107-021-5-15-00123456789101112131415182021232427282930313233W0210169

Crathco®5311 & 5511 Manual Page 275311 Base Assembly Refrigeration1234567891011121314151617181920W0650501W0200314W0650112W0200123W0200256W0650104W

Crathco®5311 & 5511 Manual Page 285511 Base Assembly Refrigeration123456710111213141516171819202122232425262728293031W0650501W0200301W0650112W0200

WARNING LABELSOPERATOR'S SAFETY PRECAUTIONS1) Read and understand the operating instructions in this manual thoroughly.2) Note all warning label

Crathco®5311 & 5511 Manual Page 29Exploded View Probe AssemblyS.S PROBE - W0572362ACETAL DELRIN SLEEVE - W0572361ADD SILICON SEALANT TO BACK OF SL

Crathco®5311 & 5511 Manual Page 3012Rough Sideof CeramicSmoothShiney SideCRATHCO MACHINE ASSEMBLYCHECK LISTSlush Cocktail Carb Tube Assy. (W047107

Crathco®5311 & 5511 Manual Page 315311 Electrical ComponentsItem Part Number DescriptionHSLBS & RBSFUFMDM101100R1R2TRSW2SCRCCRSW1FU2CB1FU1BLT1

Crathco®5311 & 5511 Manual Page 325511 Electrical Components5511-0102-057-3-20-00

Crathco®5311 & 5511 Manual Page 335311 Front Electrical Box(CR)(CR)(CR)(CR)

Crathco®5311 & 5511 Manual Page 345511 Front Electrical Box5511-0101-057-3-20-00

Crathco®5311 Manual Page 355511 Electrical BoxItem Part Number Description1234567891011W0570603W0570617W0570655W0570916W0570638W0570934W0572451W157090

5311 Spinner Hook-Up Wiring DiagramCrathco®5311 & 5511 Manual Page36

Crathco®5311 & 5511 Manual Page 375511 Spinner Hook-Up Wiring Diagram5511-0100-057-9-14-00

Crathco®5311 & 5511 Manual Page 385311 Compressor Wiring Diagram5511 Compressor Wiring Diagram5511-0106-057-3-20-00

Crathco®5311 & 5511 Manual Page 3Removal from Carton and Pallet1) Remove staples or cut cardboard box around the stapled area.2) Pull the cardboa

Crathco®5311 & 5511 Manual Page 395311 Ladder Diagram 115V 60 hz

Crathco®5311 & 5511 Manual Page 405511 Ladder Diagram 208/230V/50 Hz5511-0103-057-3-20-00

Crathco®5311 & 5511 Manual Page 415311 Wiring DiagramItem Part Number Description12345678910111213141516171819W0570603W0570617W0570655W0570423W057

Crathco®5311 & 5511 Manual Page 425511 Wiring Diagram5511-0216-057-10-25-00Item Part Number Description123467101112141516171819202122*23*24*25*26*

Crathco®5311 & 5511 Manual Page 43Refrigeration Circuit

Crathco®5311 & 5511 Manual Page 4Installation of Concealed Air Filter AccessoryKit (optional)1) Remove the four screws that hold the right side p

Crathco®5311 & 5511 Manual Page 5OPERATING & ADJUSTMENTSHow to Operate:1) Sanitize unit following the cleaning instructions on page 11.2) Fil

Carburetor AssemblyYour new freezer uses a metering device, known as a carburetor, to feed the proper ratio of mix and air into thefreezing cylinder.

Crathco®5311 & 5511 Manual Page 7Computing Overrun (cont.)3) Draw a heaping cup of frozen product that contains no air pockets. Note: Use a spatul

Mix Low Function (cont.)buzzer is out of the circuit and the light will illuminate fully again. After the 10-minute cycle the mix out safety func-tion